OLYMPIC TORCH RELAY ARRIVES AT JFK

paul horner from DHL -EMA
-you would never have guessed wearing that jacket and on a big yellow plane-
carrying the flame for the special olympics to JFK airport.

FLAME OF HOPE ARRIVES AT JFK

AT 05.44HRS THE FLAME OF HOPE FOR THE SPECIAL OLYMPICS ARRIVED AT JOHN F KENNEDY AIRPORT NEW YORK ON ROUTE FROM EAST MIDLANDS AIRPORT ON A LUFTHANSA FREIGHTER COURTESY OF DHL

SL lamp information

hi ola,
the SL for side lit or workmans lamp was used alongside the relighters. workman were not allowed to relight underground.they started phasing them out in the late 70's.
the SL was lit by a low voltage electric current in the lamp room.
the principle of the davy gauze is that the flame will burn inside the gauze but the size of the mild steel gauze ie; 28swg wire with 28 holes per inch sufficiently dissipates the heat so as not to ignite methane or firedamp outside the gauze. so when methane is present it burns in a flame on top of the lamp flame and the height gives the percentage of methane present and thus warns of an explosive atmosphere.
re lighting underground if you relight a lamp in an explosive atmosphere it will detonate and cause an explosion.
re the fuel tank or vessel, the felts inside are designed to soak up the fuel. the filling technique is to fill to the top leave 5 minutes then stand the vessel upside down to drain off the excess fuel. whats left will be sufficient to last 8-12 hours ie a normal shift.
most older pit lamps leak ad it is very difficult to reseal. but if you follow the above you should be ok.
regards david

Thank you VERY much for the quick and thorough answer David. I really appreciate it!

Mine is the one with the platinum wire lighter - were those in use before or after the flint ones?

Also - I was wondering a bit about what actually made the lamps safe in gas - is it because the gauzes makes for an increae of nitrogen making the mixture of gases inside the lamp less flameable?

I have failed to find a really good explanation for how the lamp actually works among all info on the net.

One last thing about my lamp; There seems to be a small leak in the bottom soldering on the tank - Do you think I could blow-torch it to seal it again? Or should I use some chemical seal ? I wouldn?t want to burn the felt inside...

Thanks again for the answer!

Regards,

Ola

TYPE 6 LAMP HELP

SOME QUESTIONS AND ANSWERS ABOUT A LAMP

hi ola,
the type 6 is a deputies relighter lamp which we supplied in bulk from nationalisation in 1947 to the ministry of power subsequently the national coal board and then british coal.the type 6 began to be replaced by the garforth/GR6S lamp from 1965.
the number 61 stamped on the bonnet is the miner check number. checks are handed in at the lift gate so they know who is underground.
50/ is for made in 1950.
the fuel tank or vessel is packed with felt pads to absorb the fuel,colzalene or relighter spirit which is similar to petrol. you can use petrol or ronson or zippo lighter fuel. in addition there is a long section of wick coming up to the bottom of the wick tube. this must not be removed. on top of this fits the trimming wick approx 1" long which is replaced regularly in the pits.
the felt pads and wick dry out with lack of use.
best policy is to leave it submerged in a can of petrol for a day or two.
the reason paraffin is not used is it will not light with the spark ignition, it needs a naked flame. as the lamp is a flame trap and self extinguishing if dismantled a flame cannot be introduced.
the cracks in the wick tube will not help but it shiuld still burn.
it is called a mag lock bceause it needs magnet to pull down the sprung metal pin.

the innstruction manual comes in the service pack which you can buy online at www.protectorlamp.co.uk
good luck.
regards david mather

Ola Dahlbom wrote:

Hi!

I realize you probably get a bunch of these questions but I´d very much appreciate it if you might help me out a bit:

Firts of all the age.

My lamp is stamped no. 61 on the bonnet - I gather this is just a serial?

On the bottom plate just beside the sixth locker pin which goes up in the bonnet and locks it, is stamped: 50/4026G does this tell you anything?

About the tank:

Is it filled with cotton? If I look down the wick-tube, after removing the wick, it looks like another wick is stuck some 3/4 down. I put a small screwdriver down the tube and pushed and it´s very hard.

I filled the tank with parafine and it runs for a few minutes then it seems it´s not getting enough fuel and starts burning the wick. Is it the fuel that´s wrong?

I also noted that the wick tube is broken; two small cracks runs at each side from the top to near the bottom - does this make for bad capillary force in the wick?

And last: How ist the lock suppose to work? Is it merely a push-spring bolt that´s supposed to go through the hole in the lock? If so - Why is it called a magnet lock?

Again, I hope you don´t mind these questions - I really want my beautiful lamp to work!

Thanks and regards,

Ola Dahlbom

P.S.

Is the a manual for this type of lamp? On the web?

International Mining Memorabilia Fair France

International
Mining Memorabilia Fair
October 14 2007 From 8am to 5pm
Bully les mines France
Miner's lamps, Taillettes, Medals, Tools, Clothing,
Bars, Minerals, Gaillettes, Postcards, Stamps,
Documents, Photographs, films etc.

OLYMPIC TORCH RELAY ARRIVES IN UK

THE OLYMPIC FLAME OF THE SPECIAL OLYMPICS TORCH RELAY LANDED AT EAST MIDLANDS AIRPORT THIS MORNING ON A LUFTHANSA MD11 ON ROUTE FROM COLOGNE. THE FLAME CARRIED IN 2 PROTECTOR TORCH RELAY LAMPS WAS THEN BEING DRIVEN TO LONDON TO BE PRESENTED TO THE MAYOR KEN LIVINGSTONE.
FOR MORE INFO ON THE TORCH RUN CLICK ON THE PHOTO

Special Olympics Shanghai Torch Relay 2007

THE TORCH RELAY GETS UNDERWAY COURTESY OF DHL AND ITS STAFF.
TO FOLLOW THE TORCH RUN CLICK HERE

PROTECTOR LAMP GOES YOU TUBE

YOU CAN NOW SEE VIDEOS ON SERVICING YOUR LAMP ON OUR WEB SITE AND AT YOU TUBE.
USE THESE LINKS
PROTECTOR LAMP SERVICING
PROTECTOR LAMP SERVICING 2
protectorlamp.com

Lamp Presentation

Alan Mabbett(on the left) the operations manager of Total Coal South Africa presenting a Protector Lamp to Yves-Louis Darricarrere who at the time was the Divisional President of the Gas & Power division of Total.

Forzando Colliery South Africa

Forzando Colliery, a mine operated by Total Coal South Africa.

Law Enforcement Torch Run® for Special Olympics

Three uniformed officers and another volunteer,posing outside of the stadium at Iowa State University where Opening Ceremonies for the 2006 USA National Special Olympics Games were held. The night this picture was taken, the Final Leg team, made up of police officers from around the country, ran with the Flame into the ceremony and lit the cauldron to mark the start of the Games.
The officers are holding a Protector Torch Relay Lamp and a Koehler Bright Star Lamp.

for more on Special Olympics click this link

Pan American Games Rio 2007 Torch Relay

this summer will see 6 protector torch relay lamps used in transporting the flame for the Rio Games.
XV Pan American Games Rio 2007

Special Olympics Shanghai Torch Relay 2007

june will see one of the largest torch relays when the olympic flame travels the world prior to the 2007 World Summer Games in Shanghai in October.
the protector torch relay lamp will be used to carry the flame on DHL aircraft.
Summer Games 2007

CLEARWELL CAVES TRIAL OUR NEW CAP LAMP

Clearwell Caves, the Royal Forest of Dean's
Iron Mining Museum is currently using one
of our latest cap lamps.
for more information on
clearwell click this link

HATFIELD COLLIERY

POWERFUELS RECENTLY REOPENED HATFIELD COLLIERY IS EXPANDING RAPIDLY AND NOW EMPLOYS 200 MEN.
FOR MORE INFORMATION GO TO THE ENERGY BLOG

MALTBY COLLIERY

GEOFF BIRCH IN THE LAMP ROOM AT MALTBY MARCH 2007

ASIAN GAMES TORCH RELAY

the emir of doha's son carrying the torch relay flame for the games in january in one of our lamps.

Beamish to create lamp room

for more about beamish museum click this link

CAP LAMP TRIAL AT WINSFORD ROCK SALT MINE

TO FIND OUT MORE ABOUT SALT UNION AND THE MINE CLICK HERE

M1 CAP LAMPS ON TRIAL

THE LAMPS ARE NOW ON TRIAL AT THE MINES OF BRITISH GYPSUM IN THE UK, AT THE REOPENED HATFIELD COLLIERY IN YORKSHIRE AND AT CLEVELAND POTASH'S BOULBY MINE.
FOR MORE INFORMATION ON THESE MINING OPERATIONS VISIT THE LINKS
BRITISH GYPSUM
POWERFUEL
CLEVELAND POTASH